An extensive experimental analysis on the subject of the unsteady periodic flow in a high subsonic high pressure (HP) turbine stage has been carried out at the Laboratorio di Fluidodinamica delle Macchine of the Politecnico di Milano (Italy). In this paper the aerodynamic blade row interaction in HP turbines, enforced by increasing the stator and rotor blade loading and by reducing the stator-rotor axial gap, is studied in detail. The time-averaged three-dimensional flowfield in the stator-rotor gap was investigated by means of a conventional five-hole probe for the nominal (0 deg) and highly positive $(+22 deg)$ stator incidences. The evolution of the viscous flow structures downstream of the stator is presented to characterize the rotor incoming flow. The blade row interaction was evaluated on the basis of unsteady aerodynamic measurements at the rotor exit, performed with a fast-response aerodynamic pressure probe. Results show a strong dependence of the time-averaged and phase-resolved flowfield and of the stage performance on the stator incidence. The structure of the vortex-blade interaction changes significantly as the magnitude of the rotor-inlet vortices increases, and very different residual traces of the stator secondary flows are found downstream of the rotor. On the contrary, the increase in rotor loading enhances the unsteadiness in the rotor secondary flows but has a little effect on the vortex-vortex interaction. For the large axial gap, a reduction of stator-related effects at the rotor exit is encountered when the stator incidence is increased as a result of the different mixing rate within the cascade gap.

1.
Giles
,
M. B.
, 1988, “
,”
J. Propul. Power
0748-4658,
4
, pp.
356
362
.
2.
Stieger
,
R. D.
, and
Hodson
,
H. P.
, 2005, “
The Unsteady Development of a Turbulent Wake Through a Downstream Low-Pressure Turbine Blade Passage
,”
ASME J. Turbomach.
0889-504X,
127
, pp.
388
394
.
3.
Sharma
,
O. P.
,
Pickett
,
G. F.
, and
Ni
,
R. H.
, 1992, “
Assessment of Unsteady Flows in Turbines
,”
ASME J. Turbomach.
0889-504X,
114
, pp.
79
90
.
4.
,
V. S. P.
,
Kalfas
,
A. I.
,
Benieghbal
,
M. R.
,
Hodson
,
H. P.
, and
Denton
,
J. D.
, 2001, “
Blade-Row Interaction in a High-Pressure Turbine
,”
J. Propul. Power
0748-4658,
17
, pp.
892
901
.
5.
,
V. S. P.
,
Kalfas
,
A. I.
,
Hodson
,
H. P.
,
Ohyama
,
H.
, and
Watanabe
,
E.
, 2003, “
Blade Row Interaction in High-Pressure Steam Turbine
,”
ASME J. Turbomach.
0889-504X,
125
, pp.
14
24
.
6.
Pullan
,
G.
, and
Denton
,
J. D.
, 2003, “
Numerical Simulation of Vortex-Turbine Blade Interaction
,”
Proceedings of the Fifth European Conference on Turbomachinery
.
7.
Gaetani
,
P.
,
Persico
,
G.
,
Dossena
,
V.
, and
Osnaghi
,
C.
, 2007, “
Investigation of the Flow Field in a HP Turbine Stage for Two Stator-Rotor Axial Gaps, Part I: 3D Time Averaged Flow Field
,”
ASME J. Turbomach.
0889-504X,
129
, pp.
572
579
.
8.
Gaetani
,
P.
,
Persico
,
G.
,
Dossena
,
V.
, and
Osnaghi
,
C.
, 2007, “
Investigation of the Flow Field in a HP Turbine Stage for Two Stator-Rotor Axial Gaps, Part II: Unsteady Flow Field
,”
ASME J. Turbomach.
0889-504X,
129
, pp.
580
590
.
9.
Persico
,
G.
, 2006, “
Unsteady Aerodynamic Stator-Rotor Interaction in High Pressure Turbines
,” Ph.D. thesis, Politecnico di Milano, Italy.
10.
Persico
,
G.
,
Gaetani
,
P.
, and
Guardone
,
A.
, 2005, “
Dynamic Calibration of Fast-Response Probes in Low-Pressure Shock Tubes
,”
Meas. Sci. Technol.
0957-0233,
16
, pp.
1751
1759
.
11.
Persico
,
G.
,
Gaetani
,
P.
, and
Guardone
,
A.
, 2005, “
Design and Analysis of New Concept Fast-Response Pressure Probes
,”
Meas. Sci. Technol.
0957-0233,
16
, pp.
1741
1750
.
12.
Tan
,
C.
,
Yamamoto
,
A.
,
Mizuki
,
S.
, and
Asaga
,
Y.
, 2002, “
,” AIAA Paper No. 2002-0378.
13.
Gaetani
,
P.
,
Persico
,
G.
, and
Osnaghi
,
C.
, 2007, “
,”
Proceedings of the Seventh European Conference on Turbomachinery
.
14.
Yamamoto
,
A.
, 1988, “
Interaction Mechanisms Between Tip Leakage Flow and the Passage Vortex in a Linear Turbine Rotor Cascade
,”
ASME J. Turbomach.
0889-504X,
110
, pp.
329
338
.
15.
Lecfort
,
M. D.
, 1965, “