The parabolic trough collector (PTC) is one of the most widely deployed concentrating solar power technology in the world. This study aims at improving the operational efficiency of the commercially available LS-2 solar collector by increasing the convective heat transfer coefficient inside the receiver tube. The two main factors affecting this parameter are the properties of the working fluid and the inner geometry of the receiver tube. An investigation was carried out on six different working fluids: pressurized water, supercritical CO2, Therminol VP-1, and the addition of CuO, Fe3O4, and Al2O3 nanoparticles to Therminol VP-1. Furthermore, the influence of a converging-diverging tube with sine geometry is investigated because this geometry increases the heat transfer surface and enhances turbulent flow within the receiver. The results showed that of all the fluids investigated, the Al2O3/Oil nanofluid provides the best improvement of 0.22% to thermal efficiency, while the modified geometry accounted for a 1.13% increase in efficiency. Other parameters investigated include the exergy efficiency, heat transfer coefficient, outlet temperatures, and pressure drop. The analysis and modeling of a parabolic trough receiver are implemented in engineering equation solver (EES).
Issue Section:
Research Papers
References
1.
Najjar
, Y. S. H.
, and Sadeq
, J.
, 2012
, “Modeling and Simulation of Solar Thermal Power System Using Parabolic Trough Collector
,” J. Energy Eng. ASCE
, 143
(2
), pp. 1
–9
.2.
Okonkwo
, E. C.
, Okwose
, C. F.
, and Abbasoglu
, S.
, 2017
, “Techno-Economic Analysis of the Potential Utilization of a Hybrid PV-Wind Turbine System for Commercial Buildings in Jordan
,” Int. J. Renewable Energy Res.
, 7
(2
), pp. 908
–914
.http://www.ijrer.org/ijrer/index.php/ijrer/article/view/5735/pdf3.
Hernández-Román
, M. Á.
, Manzano-Ramírez
, A.
, Pineda-Piñón
, J.
, and Ortega-Moody
, J.
, 2014
, “Exergetic and Thermoeconomic Analyses of Solar Air Heating Processes Using a Parabolic Trough Collector
,” Entropy
, 16
(8
), pp. 4612
–4625
.4.
Abid
, M.
, Ratlamwala
, T. A. H.
, and Atikol
, U.
, 2015
, “Performance Assessment of Parabolic Dish and Parabolic Trough Solar Thermal Power Plant Using Nanofluids and Molten Salts
,” Int. J. Energy Res
, 40
(4
), pp. 550
–563
.5.
Kalogirou
, S.
, 2009
, Solar Energy Engineering: Processes and Systems
, Elsevier
, Amsterdam, The Netherlands
.6.
Duffie
, J. A.
, and Beckman
, W. A.
, 2013
, Solar Engineering of Thermal Processes Solar Engineering
, Wiley
, New York.7.
Behar
, O.
, Khellaf
, A.
, and Mohammedi
, K.
, 2015
, “A Novel Parabolic Trough Solar Collector Model—Validation With Experimental Data and Comparison to Engineering Equation Solver (EES)
,” Energy Convers. Manage.
, 106
, pp. 268
–281
.8.
Kalogirou
, S. A.
, 2004
, “Solar Thermal Collectors and Applications
,” Prog. Energy Combust. Sci.
, 30
(3
), pp. 231
–295
.9.
Bellos
, E.
, Tzivanidis
, C.
, Antonopoulos
, K. A.
, and Gkinis
, G.
, 2016
, “Thermal Enhancement of Solar Parabolic Trough Collectors by Using Nanofluids and Converging-Diverging Absorber Tube
,” Renewable Energy
, 94
, pp. 213
–222
.10.
Fuqiang
, W.
, Ziming
, C.
, Jianyu
, T.
, Yuan
, Y.
, Yong
, S.
, and Linhua
, L.
, 2017
, “Progress in Concentrated Solar Power Technology With Parabolic Trough Collector System: A Comprehensive Review
,” Renewable Sustainable Energy Rev.
, 79
, pp. 1314
–1328
.11.
Bergman
, T. L.
, Lavigne
, A. S.
, and Incropera
, F. P.
, 2011
, Fundamentals of Heat and Mass Transfer
, 7th ed., Wiley
, Hoboken, NJ.12.
Mwesigye
, A.
, and Meyer
, J. P.
, 2017
, “Optimal Thermal and Thermodynamic Performance of a Solar Parabolic Trough Receiver With Different Nanofluids and at Different Concentration Ratios
,” Appl. Energy
, 193
, pp. 393
–413
.13.
Amina
, B.
, Miloud
, A.
, Samir
, L.
, Abdelylah
, B.
, and Solano
, J. P.
, 2016
, “Heat Transfer Enhancement in a Parabolic Trough Solar Receiver Using Longitudinal Fins and Nanofluids
,” J. Therm. Sci.
, 25
(5
), pp. 410
–417
.14.
Chamkha
, A. J.
, Miroshnichenko
, I. V.
, and Sheremet
, M. A.
, 2017
, “Numerical Analysis of Unsteady Conjugate Natural Convection of Hybrid Water-Based Nanofluid in a Semi-Circular Cavity
,” ASME J. Therm. Sci. Eng. Appl.
, 9
(4
), p. 041004.15.
Sokhansefat
, T.
, Kasaeian
, A. B.
, and Kowsary
, F.
, 2014
, “Heat Transfer Enhancement in Parabolic Trough Collector Tube Using Al2O3/Synthetic Oil Nanofluid
,” Renewable Sustainable Energy Rev.
, 33
, pp. 636
–644
.16.
Hung
, Y. H.
, Teng
, T. P.
, and Lin
, B. G.
, 2013
, “Evaluation of the Thermal Performance of a Heat Pipe Using Alumina Nanofluids
,” Exp. Therm. Fluid Sci.
, 44
, pp. 504
–511
.17.
Hussein
, A. K.
, 2016
, “Applications of Nanotechnology to Improve the Performance of Solar Collectors—Recent Advances and Overview
,” Renewable Sustainable Energy Rev.
, 62
, pp. 767
–790
.18.
Shojaeizadeh
, E.
, Veysi
, F.
, and Kamandi
, A.
, 2015
, “Exergy Efficiency Investigation and Optimization of an Al2O3–Water Nanofluid Based Flat-Plate Solar Collector
,” Energy Build.
, 101
, pp. 12
–23
.19.
Ghozatloo
, A.
, Rashidi
, A.
, and Shariaty-Niassar
, M.
, 2014
, “Convective Heat Transfer Enhancement of Graphene Nanofluids in Shell and Tube Heat Exchanger
,” Exp. Therm. Fluid Sci.
, 53
, pp. 136
–141
.20.
Mwesigye
, A.
, Huan
, Z.
, and Meyer
, J. P.
, 2015
, “Thermodynamic Optimisation of the Performance of a Parabolic Trough Receiver Using Synthetic Oil–Al2O3 Nanofluid
,” Appl. Energy
, 156
, pp. 398
–412
.21.
Hussein
, A. M.
, Sharma
, K. V.
, Bakar
, R. A.
, and Kadirgama
, K.
, 2013
, “The Effect of Nanofluid Volume Concentration on Heat Transfer and Friction Factor Inside a Horizontal Tube
,” J. Nanomater.
, 2013
, p. 859563.22.
Loni
, R.
, Asli-ardeh
, E. A.
, Ghobadian
, B.
, Kasaeian
, A. B.
, and Gorjian
, S.
, 2017
, “Thermodynamic Analysis of a Solar Dish Receiver Using Different Nanofluids
,” Energy
, 133
, pp. 749
–760
.23.
Yousefi
, T.
, Veysi
, F.
, Shojaeizadeh
, E.
, and Zinadini
, S.
, 2012
, “An Experimental Investigation on the Effect of Al2O3-H2O Nanofluid on the Efficiency of Flat-Plate Solar Collectors
,” Renewable Energy
, 39
(1
), pp. 293
–298
.24.
Coccia
, G.
, Di Nicola
, G.
, Colla
, L.
, Fedele
, L.
, and Scattolini
, M.
, 2016
, “Adoption of Nanofluids in Low-Enthalpy Parabolic Trough Solar Collectors: Numerical Simulation of the Yearly Yield
,” Energy Convers. Manage.
, 118
, pp. 306
–319
.25.
Wang
, Y.
, Xu
, J.
, Liu
, Q.
, Chen
, Y.
, and Liu
, H.
, 2016
, “Performance Analysis of a Parabolic Trough Solar Collector Using Al2O3/Synthetic Oil Nanofluid
,” Appl. Therm. Eng.
, 107
, pp. 469
–478
.26.
Khakrah
, H.
, Shamloo
, A.
, and Kazemzadeh Hannani
, S.
, 2017
, “Determination of Parabolic Trough Solar Collector Efficiency Using Nanofluid: A Comprehensive Numerical Study
,” ASME J. Sol. Energy Eng.
, 139
(5
), p. 051006
.27.
Yousefi
, T.
, Veisy
, F.
, Shojaeizadeh
, E.
, and Zinadini
, S.
, 2012
, “An Experimental Investigation on the Effect of MWCNT-H2O Nanofluid on the Efficiency of Flat-Plate Solar Collectors
,” Exp. Therm. Fluid Sci.
, 39
, pp. 207
–212
.28.
Kasaeian
, A.
, Daneshazarian
, R.
, Rezaei
, R.
, Pourfayaz
, F.
, and Kasaeian
, G.
, 2017
, “Experimental Investigation on the Thermal Behavior of Nanofluid Direct Absorption in a Trough Collector
,” J. Clean. Prod.
, 158
, pp. 276
–284
.29.
Kasaeian
, A.
, Daneshazarian
, R.
, and Pourfayaz
, F.
, 2017
, “Comparative Study of Different Nanofluids Applied in a Trough Collector With Glass-Glass Absorber Tube
,” J. Mol. Liq.
, 234
, pp. 315
–323
.30.
Budisa
, N.
, and Schulze-Makuch
, D.
, 2014
, “Supercritical Carbon Dioxide and Its Potential as a Life-Sustaining Solvent in a Planetary Environment
,” Life
, 4
(3
), pp. 331
–340
.31.
Qiu
, Y.
, Li
, M.-J.
, He
, Y.-L.
, and Tao
, W.-Q.
, 2017
, “Thermal Performance Analysis of a Parabolic Trough Solar Collector Using Supercritical CO2 as Heat Transfer Fluid Under Non-Uniform Solar Flux
,” Appl. Therm. Eng.
, 115
, pp. 1255
–1265
.32.
Pitla
, S. S.
, Groll
, E. A.
, Robinson
, D. M.
, and Ramadhyani
, S.
, 1998
, “Heat Transfer From Supercritical Carbon Dioxide in Tube Flow: A Critical Review
,” HVACR Res.
, 4
(3
), pp. 281
–301
.33.
Liao
, S. M.
, and Zhao
, T. S.
, 2002
, “An Experimental Investigation of Convection Heat Transfer to Supercritical Carbon Dioxide in Miniature Tubes
,” Int. J. Heat Mass Transfer
, 45
(25
), pp. 5025
–5034
.34.
Jiang
, P. X.
, Zhao
, C.-R.
, Deng
, J.-Q.
, and Zhang
, W.-X.
, 2008
, “Experimental Investigation of Local Heat Transfer of Carbon Dioxide at Super-Critical Pressures in a Vertical Tube and Multi-Port Mini-Channels Under Cooling Conditions
,” International Refrigrator Air Conditioning Conference
, West Lafayette, IN, July 14–17, pp. 1
–8
.https://docs.lib.purdue.edu/cgi/viewcontent.cgi?article=1891&context=iracc35.
Jaramillo
, O. A.
, Borunda
, M.
, Velazquez-Lucho
, K. M.
, and Robles
, M.
, 2016
, “Parabolic Trough Solar Collector for Low Enthalpy Processes: An Analysis of the Efficiency Enhancement by Using Twisted Tape Inserts
,” Renewable Energy
, 93
, pp. 125
–141
.36.
Bharadwaj
, P.
, Khondge
, A. D.
, and Date
, A. W.
, 2009
, “Heat Transfer and Pressure Drop in a Spirally Grooved Tube With Twisted Tape Insert
,” Int. J. Heat Mass Transfer
, 52
(7–8
), pp. 1938
–1944
.37.
Gunes
, S.
, Ozceyhan
, V.
, and Buyukalaca
, O.
, 2010
, “Heat Transfer Enhancement in a Tube With Equilateral Triangle Cross Sectioned Coiled Wire Inserts
,” Exp. Therm. Fluid Sci.
, 34
(6
), pp. 684
–691
.38.
Mwesigye
, A.
, Bello-Ochende
, T.
, and Meyer
, J. P.
, 2013
, “Heat Transfer Enhancement in a Parabolic Trough Receiver Using Wall Detached Twisted Tape Inserts
,” ASME
Paper No. IMECE2013-62745.39.
Garg
, V. K.
, and Maji
, P. K.
, 1987
, “Flow Through a Converging-Diverging Tube With Constant Wall Enthalpy
,” Numer. Heat Transfer
, 12
(3
), pp. 285
–305
.40.
Deiber
, J. A.
, and Schowalter
, W. R.
, 1979
, “Flow Through Tubes With Sinusoidal Axial Variations in Diameter
,” AIChE J.
, 25
(4
), pp. 638
–645
.41.
Sparrow
, E. M.
, and Prata
, A. T.
, 1983
, “Numerical Solutions for Laminar Flow and Heat Transfer in a Periodically Converging-Diverging Tube, With Experimental Confirmation
,” Numer. Heat Transfer
, 6
(4
), pp. 441
–461
.42.
Yang
, M.
, Yang
, X.
, Yang
, X.
, and Ding
, J.
, 2010
, “Heat Transfer Enhancement and Performance of the Molten Salt Receiver of a Solar Power Tower
,” Appl. Energy
, 87
(9
), pp. 2808
–2811
.43.
Lu
, J.
, Sheng
, X.
, Ding
, J.
, and Yang
, J.
, 2013
, “Transition and Turbulent Convective Heat Transfer of Molten Salt in Spirally Grooved Tube
,” Exp. Therm. Fluid Sci.
, 47
, pp. 180
–185
.44.
Mohammed
, H. A.
, Al-Shamani
, A. N.
, and Sheriff
, J. M.
, 2012
, “Thermal and Hydraulic Characteristics of Turbulent Nanofluids Flow in a Rib-Groove Channel
,” Int. Commun. Heat Mass Transfer
, 39
(10
), pp. 1584
–1594
.45.
Bellos
, E.
, Tzivanidis
, C.
, and Tsimpoukis
, D.
, 2017
, “Thermal Enhancement of Parabolic Trough Collector With Internally Finned Absorbers
,” Appl. Energy
, 205
, pp. 540
–561
.46.
Muñoz
, J.
, and Abánades
, A.
, 2011
, “Analysis of Internal Helically Finned Tubes for Parabolic Trough Design by CFD Tools
,” Appl. Energy
, 88
(11
), pp. 4139
–4149
.47.
García
, A.
, Solano
, J. P.
, Vicente
, P. G.
, and Viedma
, A.
, 2012
, “The Influence of Artificial Roughness Shape on Heat Transfer Enhancement: Corrugated Tubes, Dimpled Tubes and Wire Coils
,” Appl. Therm. Eng
, 35
(1
), pp. 196
–201
.48.
Sandeep
, H. M.
, and Arunachala
, U. C.
, 2017
, “Solar Parabolic Trough Collectors: A Review on Heat Transfer Augmentation Techniques
,” Renewable Sustainable Energy Rev.
, 69
, pp. 1218
–1231
.49.
Dudley
, V. E.
, Kolb
, G. J.
, Mahoney
, A. R.
, Mancini
, T. R.
, Matthews
, C. W.
, Sloan
, M.
, Kearney
, D.
, Dudley
, V.
, Kolb
, G.
, Sloan
, M.
, and Kearney
, D.
, 1994
, “Test Results: SEGS LS-2 Solar Collector
,” Sandia National Laboratory, Albuquerque, NM, Report
.http://large.stanford.edu/publications/coal/references/troughnet/solarfield/docs/segs_ls2_solar_collector.pdf50.
Mohammad Zadeh
, P.
, Sokhansefat
, T.
, Kasaeian
, A. B.
, Kowsary
, F.
, and Akbarzadeh
, A.
, 2015
, “Hybrid Optimization Algorithm for Thermal Analysis in a Solar Parabolic Trough Collector Based on Nanofluid
,” Energy
, 82
, pp. 857
–864
.51.
Petela
, R.
, 1964
, “Exergy of Heat Radiation
,” ASME J. Heat Transfer
, 86
(2
), pp. 187
–192
.52.
Padilla
, R. V.
, Fontalvo
, A.
, Demirkaya
, G.
, Martinez
, A.
, and Quiroga
, A. G.
, 2014
, “Exergy Analysis of Parabolic Trough Solar Receiver
,” Appl. Therm. Eng.
, 67
(1–2
), pp. 579
–586
.53.
Solutia,
2014
, “Therminol VP-1. 1–5
,” Solutia, St. Louis, MI, accessed May 4, 2018, http://twt.mpei.ac.ru/tthb/hedh/htf-vp1.pdf54.
Abid
, M.
, Ratlamwala
, T. A. H.
, and Atikol
, U.
, 2017
, “Solar Assisted Multi-Generation System Using Nanofluids: A Comparative Analysis
,” Int. J. Hydrogen Energy
, 42
(33
), pp. 21429
–21442
.55.
Hassani
, S.
, Saidur
, R.
, Mekhilef
, S.
, and Hepbasli
, A.
, 2015
, “A New Correlation for Predicting the Thermal Conductivity of Nanofluids; Using Dimensional Analysis
,” Int. J. Heat Mass Transfer
, 90
, pp. 121
–130
.56.
Khanafer
, K.
, and Vafai
, K.
, 2011
, “A Critical Synthesis of Thermophysical Characteristics of Nanofluids
,” Int. J. Heat Mass Transfer
, 54
(19–20
), pp. 4410
–4428
.57.
Batchelor
, G. K.
, 1977
, “The Effect of Brownian Motion on the Bulk Stress in a Suspension of Spherical Particles
,” J. Fluid Mech.
, 83
(1
), pp. 97
–117
.58.
Sharma
, K. V.
, Azmi
, W. H.
, Kamal
, S.
, Sarma
, P. K.
, and Vijayalakshmi
, B.
, 2016
, “Theoretical Analysis of Heat Transfer and Friction Factor for Turbulent Flow of Nanofluids Through Pipes
,” Can. J. Chem. Eng.
, 94
(3
), pp. 565
–575
.59.
Gnielinski
, V.
, 1976
, “New Equations for Heat and Mass Transfer in Turbulent Pipe and Channel Flow
,” Int. Chem. Eng.
, 16
(2
), pp. 359
–368
.https://www.scopus.com/record/display.uri?eid=2-s2.0-84964527772&origin=inward&txGid=29bbc0607155b23c55890d2c80457a0c60.
Xuan
, Y.
, and Li
, Q.
, 2003
, “Investigation on Convective Heat Transfer and Flow Features of Nanofluids
,” ASME J. Heat Transfer
, 125
(1
), pp. 151
–155
.61.
Forristall
, R.
, 2003
, “Heat Transfer Analysis and Modeling of a Parabolic Trough Solar Receiver Implemented in Engineering Equation Solver
,” National Renewable Energy Laboratory, Golden, CO, Report No. NREL/TP-550-34169
.https://www.nrel.gov/docs/fy04osti/34169.pdf62.
Jamali
, H.
, 2016
, “Analyses of Absorber Tube of Parabolic Trough Solar Collector (PTSC) Based on Convective Heat Transfer Coefficient of Fluid
,” Int. Energy J.
, 16
(2), pp. 73
–86
.http://www.rericjournal.ait.ac.th/index.php/reric/article/view/1332/47363.
Ma
, Z.
, and Turchi
, C.
, 2011
, “Advanced Supercritical Carbon Dioxide Power Cycle Configurations for Use in Concentrating Solar Power Systems
,” Supercritical CO2 Power Cycle Symposium
, Boulder, CO, May 24–25, pp. 4
–7
.https://www.nrel.gov/docs/fy11osti/50787.pdf64.
AnthroPower,
2014
, “Parabolic Trough Based Solar System Operations & Maintenance Manual
,” AnthroPower, New Delhi, India, accessed May 4, 2018, https://mnre.gov.in/file-manager/UserFiles/CST-Manuals/PTC_E.pdfCopyright © 2018 by ASME
You do not currently have access to this content.
