Abstract
Gas-in-riser events can lead to rapid unloading if not timely controlled in a proper manner. When gas influx enters a wellbore with non-aqueous muds (NAMs), the ability of gas being dissolved in NAMs increases the difficulty in gas kick detection and significantly alters gas migration and unloading behavior from the predictions based on water-based muds (WBMs) assumptions.
In this study, a new mathematical model for riser gas management in NAMs is developed. In this model, the desorption of dissolved gas influx from NAMs is accounted for as an instantaneous process using a solubility-based mass transfer submodel. The effects of surface backpressures and circulation rates on the unloading behavior in both WBMs and NAMs were studied. This model was validated using data obtained from a drift-flux model (DFM) based simulator. Results show that with the same amount of free gas in the risers at the mudline level, the severity of unloading is significantly more severe in the cases of NAMs. Applied backpressure can effectively control the desorption of the gas influx from the mud, and the unloading occurs later and at shallower depth with higher backpressure. The behavior of unloading tends to be independent on the time when backpressures are applied but highly dependent on the magnitude of the backpressure and the circulation rates. The new two-phase model can accurately simulate riser gas kick events utilizing a simplified approach with improved numerical stability, making it more applicable for real-time riser gas management.
Issue Section:
Petroleum Engineering
References
1.
Gu
, Q.
, Fallah
, A.
, Ambrus
, A.
, Ma
, Z.
, Chen
, D.
, Ashok
, P.
, and van Oort
, E.
, 2020
, “A Switching MPD Controller for Mitigating Riser Gas Unloading Events in Offshore Drilling
,” SPE Drill. Completion
, pp. 1
–17
. 10.2118/194163-pa2.
Huaizhong
, S.
, Heqian
, Z.
, Zhaosheng
, J.
, Jingbin
, L.
, Xinxu
, H.
, and Shijie
, Z.
, 2019
, “Numerical Simulation and Experimental Study of Cuttings Transport in Narrow Annulus
,” ASME J. Energy Resour. Technol.
, 141
(8
), p. 082902
. 10.1115/1.40424483.
Aarsnes
, U. J. F.
, Hauge
, E.
, and Godhavn
, J. M.
, 2016
, “Mathematical Modeling of Gas in Riser
,” SPE-108292-MS Paper Presented at the 2016 SPE Deepwater Drilling and Completions Conference Held in Galveston
, Galveston, TX
, Sept. 14–15
.4.
Yeo
, M.
, Macgregor
, A. J.
, Pinkstone
, H.
, and Piccolo
, B.
, 2015,
, “Offshore Deepwater Managed Pressure Drilling and Riser gas Handling Equipment Design
,” SPE/IADC Managed Pressure Drilling and Underbalanced Operations Conference and Exhibition
, Dubai, UAE
, Apr. 13–14
.5.
Kinik
, K.
, Gumus
, F.
, and Osayande
, N.
, 2015
, “Automated Dynamic Well Control With Managed-Pressure Drilling: A Case Study and Simulation Analysis
,” SPE Drill. Completion
, 30
(2
), pp. 110
–118
. 10.2118/168948-PA6.
Cenberlitas
, S.
, Crenshaw
, J.
, Gumus
, F.
, and Alpaugh
, K.
, 2011
, “MPD Technique in Haynesville Shale Delivers Significant Value in Over Pressured Zones: A Case Study on Four Wells
,” Proceedings of 2011 AADE National Technical Conference and Exhibition
, American Association of Drilling Engineers
, Houston, TX
, Apr.
, pp. 12
–14
.7.
Gedge
, B.
, Singh
, D.
, Kaur
, H.
, Bandico Refugio
, E.
, Ta Quoc
, B.
, and Bot
, N. V.
, 2013
, “Managed Pressure Drilling—A Solution for Drilling the Challenging and Un-Drillable Wells in Vietnam and South East Asia
,” SPE Asia Pacific Oil and Gas Conference and Exhibition
, Jakarta, Indonesia
, Oct. 22–24
.8.
Gravdal
, J. E.
, Nikolaou
, M.
, and Breyholtz
, Ø
, 2010
, “Improved Kick Management During MPD by Real-Time Pore-Pressure Estimation
,” SPE J.
, 25
(4
), pp. 577
–584
. 10.2118/124054-pa9.
Malik
, H.
, Litwin
, R. J.
, and Jones
, B.
, 2010
, “Successful Use of Managed Pressure Drilling (MPD) to Counteract Loss Circulation and HP Gas Zones: A Case Study From Red Rock South Wapiti Field in GrandPrairie Alberta
,” Canadian Unconventional Resources and International Petroleum Conference
, Calgary, Alberta, Canada
, Oct. 19–21
.10.
Medina
, L.
, Baker
, J.
, Markabi
, M.
, Rojas
, J.
, Tarique
, Z.
, and Dow
, B.
, 2014
, “Automated MPD and an Engineered Solution: A Case History in Western Canada
,” IADC/SPE Drilling Conference and Exhibition
, Texas, USA
, Mar. 4–6
.11.
Qutob
, H. H.
, Vieira
, P.
, Torres
, F.
, and Arnone
, M. A.
, 2011
, “Managed Pressure Drilling Applications Proves Successful in the Middle East and North Africa Region
,” SPE/IADC Middle East Drilling Technology Conference and Exhibition
, Muscat, Oman
, Oct. 24–26
.12.
Santos
, H.
, Reid
, P.
, McCaskill
, J.
, Kinder
, J.
, and Kozics
, J.
, 2006
, “Deepwater Drilling Made More Efficient and Cost-Effective: Using the Microflux Control Method and an Ultralow-Invasion Fluid To Open the Mud-Weight Window
,” Offshore Technology Conference
, Houston, TX
, May 1–4
.13.
Vieira
, P.
, Arnone
, M. A.
, Cook
, I.
, Moyse
, K.
, Haojie
, H. W.
, Qutob
, H. H.
, Yuesheng
, C.
, and Qing
, C.
, 2008
, “Constant Bottomhole Pressure: Managed-Pressure Drilling Technique Applied in an Exploratory Well in Saudi Arabia
,” SPE/IADC Managed Pressure Drilling and Underbalanced Operations Conference and Exhibition
, Abu Dhabi, UAE
, Jan. 28–29
.14.
Malloy
, K. P.
, Stone
, R.
, Medley
, G. H.
, Hannegan
, D. M.
, Coker
, O. D.
, Reitsma
, D.
, Santos
, H. M.
, Kinder
, J. I.
, Eck-Olsen
, J.
, McCaskill
, J. W.
, and May
, J. R.
, 2009
, “Managed-Pressure Drilling: What it is and What it is Not
,” IADC/SPE Managed Pressure Drilling and Underbalanced Operations Conference & Exhibition
, San Antonio, TX
, Feb. 12–13
.15.
Aarsnes
, U. J. F.
, Açıkmeşe
, B.
, Ambrus
, A.
, and Aamo
, O. M.
, 2016
, “Robust Controller Design for Automated Kick Handling in Managed Pressure Drilling
,” J. Process Control
, 47
(6
), pp. 46
–57
. 10.1016/j.jprocont.2016.09.00116.
Ambrus
, A.
, Vajargah
, A. K.
, Ashok
, P.
, and van Oort
, E.
, 2017
, “Choke Controller Design for Automated Managed Pressure Drilling with Realistic Operational System Conditions
,” AADE National Technical Conference and Exhibition
, Houston, TX
, Apr. 11–12
.17.
Gu
, Q.
, Fallah
, A.
, Ambrus
, A.
, Ma
, Z.
, Chen
, D.
, Ashok
, P.
, and Oort
, E. V.
, 2019
, “A Switching Controller for Mitigating Riser Gas Unloading Hazards in Offshore Drilling
,” SPE/IADC International Drilling Conference and Exhibition
, The Hague, The Netherlands
, Mar. 5–7
.18.
Wang
, Z.
, Qiu
, Y.
, Guo
, P.
, Du
, J.
, Liu
, H.
, Hu
, Y.
, and Zeng
, F.
, 2019
, “Experimental Investigation of the Damage Mechanisms of Drilling Mud in Fractured Tight gas Reservoir
,” ASME J. Energy Resour. Technol.
, 141
(9
), p. 092907
. 10.1115/1.404324719.
Davoudi
, M.
, Smith
, J. R.
, Chirinos
, J. E.
, and Patel
, B. M.
, 2011
, “Evaluation of Alternative Initial Responses to Kicks Taken During Managed-Pressure Drilling
,” SPE Drill. Completion
, 26
(2
), pp. 169
–181
. 10.2118/128424-PA20.
Zhou
, J.
, Nygaard
, G.
, Godhavn
, J. M.
, Breyholtz
, Ø
, and Vefring
, E. H.
, 2010
, “Adaptive Observer for Kick Detection and Switched Control for Bottomhole Pressure Regulation and Kick Attenuation During Managed Pressure Drilling
,” Proceedings of the 2010 American Control Conference
, IEEE
, June
, pp. 3765
–3770
. 10.1109/acc.2010.553155121.
Gomes
, D.
, Nilsen
, M. S.
, Frøyen
, J.
, Bjørkevoll
, K. S.
, Lage
, A. C.
, Fjelde
, K. K.
, and Sui
, D.
, 2018
, “A Transient Flow Model for Investigating Parameters Affecting Kick Behavior in OBM for HPHT Wells and Backpressure MPD Systems
,” ASME 2018 37th International Conference on Ocean, Offshore and Arctic Engineering
, Madrid, Spain
, June 17–22
.22.
Velmurugan
, N.
, Godhavn
, J. M.
, and Hauge
, E.
, 2016
, “Dynamic Simulation of Gas Migration in Marine Risers
,” SPE Bergen One Day Seminar
, Grieghallen, Bergen, Norway
, Apr. 20
.23.
Yuan
, Z.
, Morrell
, D.
, Sonnemann
, P.
, and Leach
, C.
, 2017
, “Mitigating Gas-in-Riser Rapid Unloading for Deepwater-Well Control
,” SPE Drill. Completion
, 32
(2
), pp. 105
–111
. 10.2118/185179-PA24.
Gomes
, D.
, Frøyen
, J.
, Fjelde
, K. K.
, and Bjørkevoll
, K.
, 2018
, “A Numerical Comparison and Uncertainty Analysis of Two Transient Models for Kick Management in a Backpressure MPD System
,” SPE Norway One Day Seminar
, Bergen, Norway
, Apr. 18
.25.
Driedger
, D. J.
, Kelly
, S. P.
, Leggett
, C.
, Thain
, J.
, and Silva
, M.
, 2013
, “Managed Pressure Drilling Technique Applied in a Kurdistan Exploration Well
,” SPE Middle East Oil and Gas Show and Conference
, Manama, Bahrain
, Mar. 10–13
.26.
Nwaka
, N.
, and Chen
, Y.
, 2019
, “Numerical Simulations of Riser Gas Behavior in Non-Aqueous Muds Using a Modified Drift Flux Model
,” ASME 38th International Conference on Ocean, Offshore and Arctic Engineering
, Glasgow, Scotland, UK
, June 9–14
.27.
Ambrus
, A.
, Aarsnes
, U. J. F.
, Vajargah
, A. K.
, Akbari
, B.
, van Oort
, E.
, and Aamo
, O. M.
, 2016
, “Real-Time Estimation of Reservoir Influx Rate and Pore Pressure Using a Simplified Transient Two-Phase Flow Model
,” J. Nat. Gas Sci. Eng.
, 32
(42
), pp. 439
–452
. 10.1016/j.jngse.2016.04.03628.
Gonzalez
, F.
, Shaughnessy
, J.
, and Grindle
, W. D.
, 2000
, “Industry Leaders Shed Light on Drilling Riser Gas Effects
,” Oil Gas J.
, 98
(29
), pp. 42
–46
.29.
Zhang
, N.
, Li
, H.
, Zhang
, Y.
, Deng
, Q.
, and Tan
, Y.
, 2019
, “A Numerical Simulation for the Determination of the Shunt Ratio at a T-Junction With Different Branch Angles, Viscosities, and Flow Rates
,” ASME J. Energy Resour. Technol.
, 141
(10
), p. 102906
. 10.1115/1.404363530.
Redlich
, O.
, and Kwong
, J. N.
, 1949
, “On the Thermodynamics of Solutions. V. An Equation of State. Fugacities of Gaseous Solutions
,” Chem. Rev.
, 44
(1
), pp. 233
–244
. 10.1021/cr60137a01331.
Sutton
, R. P.
, 1985
, “Compressibility Factors for High-Molecular-Weight Reservoir Gases
,” SPE Annual Technical Conference and Exhibition
, Las Vegas, NV
, Sept. 22–26
.32.
Bhagwat
, S. M.
, and Ghajar
, A. J.
, 2014
, “A Flow Pattern Independent Drift Flux Model Based Void Fraction Correlation for a Wide Range of Gas–Liquid Two Phase Flow
,” Int. J. Multiphase Flow
, 59
(17
), pp. 186
–205
. 10.1016/j.ijmultiphaseflow.2013.11.00133.
Choi
, J.
, Pereyra
, E.
, Sarica
, C.
, Park
, C.
, and Kang
, J. M.
, 2012
, “An Efficient Drift-Flux Closure Relationship to Estimate Liquid Holdups of Gas-Liquid Two-Phase Flow in Pipes
,” Energies
, 5
(12
), pp. 5294
–5306
. 10.3390/en512529434.
Guo
, R.
, Chen
, Y.
, Waltrich
, P. J.
, and Williams
, W. C.
, 2018
, “An Experimental Investigation on Flow Pattern Map and Drift-Flux Model for Co-Current Upward Liquid-Gas Two-Phase Flow in Narrow Annuli
,” J. Nat. Gas Sci. Eng.
, 51
(9
), pp. 65
–72
. 10.1016/j.jngse.2017.12.02535.
Shi
, H.
, Holmes
, J.
, Diaz
, L.
, Durlofsky
, L. J.
, and Aziz
, K.
, 2005
, “Drift-Flux Parameters for Three-Phase Steady-State Flow in Wellbores
,” SPE J.
, 10
(2
), pp. 130
–137
. 10.2118/89836-PA36.
Hibiki
, T.
, and Ishii
, M.
, 2003
, “One-dimensional Drift-Flux Model and Constitutive Equations for Relative Motion Between Phases in Various Two-Phase Flow Regimes
,” Int. J. Heat Mass Transfer
, 46
(25
), pp. 4935
–4948
. 10.1016/S0017-9310(03)00322-337.
Wang
, N.
, Sun
, B.
, Wang
, Z.
, Wang
, J.
, and Yang
, C.
, 2016
, “Numerical Simulation of Two Phase Flow in Wellbores by Means of Drift Flux Model and Pressure Based Method
,” J. Nat. Gas Sci. Eng.
, 36
(72
), pp. 811
–823
. 10.1016/j.jngse.2016.10.04038.
Alghlam
, A. S.
, Stevanovic
, V. D.
, Elgazdori
, E. A.
, and Banjac
, M.
, 2019
, “Numerical Simulation of Natural Gas Pipeline Transients
,” ASME J. Energy Resour. Technol.
, 141
(10
), p. 102002
. 10.1115/1.404343639.
Shi
, H.
, Song
, H.
, Zhao
, H.
, and Chen
, Z.
, 2019
, “Numerical Study of a Flow Field Near the Bit for a Coiled-Tubing Partial Underbalanced Drilling Method
,” ASME J. Energy Resour. Technol.
, 141
(10
), p. 102902
. 10.1115/1.404338840.
Zuber
, N.
, and Findlay
, J.
, 1965
, “Average Volumetric Concentration in Two-Phase Flow Systems
,” ASME J. Heat Transfer.
87
(4
) pp. 453
–468
. 10.1115/1.368913741.
Caetano
, E. F.
, 1986
, “Upward Two-Phase Flow Through an Annulus
,” Ph.D. thesis
, University of Tulsa
, OK
.42.
Lee
, A. L.
, Gonzalez
, M. H.
, and Eakin
, B. E.
, 1966
, “The Viscosity of Natural Gases
,” J. Pet. Technol.
, 18
(8
), pp. 997
–991
. 10.2118/1340-PA43.
Reynolds
, O.
, 1886
, “IV. On the Theory of Lubrication and Its Application to Mr. Beauchamp Tower’s Experiments, Including an Experimental Determination of the Viscosity of Olive Oil
,” Philos. Trans. R. Soc. London
, 177
(4
), pp. 157
–234
. 10.1098/rstl.1886.000544.
O’Bryan
, P. L.
, Bourgoyne Jr
, A. T.
, Monger
, T. G.
, and Kopcso
, D. P.
, 1988
, “An Experimental Study of Gas Solubility in Oil-Based Drilling Fluids
,” SPE Drill. Eng.
, 3
(1
), pp. 33
–42
. 10.2118/15414-PA45.
Linga
, H.
, Nilsen
, F. P.
, and Knudsen
, B. L.
, 2003
, “Prediction Model Optimises H2S Scavenger Injection Strategy
,” Sulphur
, Banff, Canada
, Nov. 2–5
.46.
Bjørkevoll
, K. S.
, Skogestad
, J. O.
, Frøyen
, J.
, and Linga
, H.
, 2018Mar
, “Well Control Simulator: Enhancing Models With Compositional PVT Models and Kinetics
,” IADC/SPE Drilling Conference and Exhibition
, Fort Worth, TX
, Mar. 6–8
.47.
Zhou
, Y.
, Wojtanowicz
, A. K.
, Li
, X.
, Miao
, Y.
, and Chen
, Y.
, 2018
, “Improved Model for Gas Migration Velocity of Stagnant non-Newtonian Fluids in Annulus
,” J. Pet. Sci. Eng.
, 168
(14
), pp. 190
–200
. 10.1016/j.petrol.2018.05.02548.
Ajayi
, T.
, and Gupta
, I.
, 2019
, “A Review of Reactive Transport Modeling in Wellbore Integrity Problems
,” J. Pet. Sci. Eng.
, 175
(62
), pp. 785
–803
. 10.1016/j.petrol.2018.12.07949.
Nwaka
, N.
, and Chen
, Y.
, 2019
, “Numerical Simulations of Riser Gas Behavior in Non-Aqueous Muds Using a Modified Drift Flux Model
,” Volume 8: Polar and Arctic Sciences and Technology, Petroleum Technology
, Glasgow, Scotland, UK
, June 9–14
.Copyright © 2020 by ASME
You do not currently have access to this content.
