Miniaturization of electronic and optoelectronic devices and circuits and increased switching speeds have exasperated localized heating problems. Steady-state and transient characterization of temperature distribution in devices and interconnects is important for performance and reliability analysis. Novel devices based on nanowires, carbon nanotubes, and single molecules have feature sizes in 1–100 nm range, and precise temperature measurement and calibration are particularly challenging. In this paper we review various microscale and nanoscale thermal characterization techniques that could be applied to active and passive devices. Solid-state microrefrigerators on a chip can provide a uniform and localized temperature profile and they are used as a test vehicle in order to compare the resolution limits of various microscale techniques. After a brief introduction to conventional microthermocouples and thermistor sensors, various contact and contactless techniques will be reviewed. Infrared microscopy is based on thermal emission and it is a convenient technique that could be used with features tens of microns in size. Resolution limits due to low emissivity and transparency of various materials and issues related to background radiation will be discussed. Liquid crystals that change color due to phase transition have been widely used for hot spot identification in integrated circuit chips. The main problems are related to calibration and aging of the material. Micro-Raman is an optical method that can be used to measure absolute temperature. Micron spatial resolution with several degrees of temperature resolution has been achieved. Thermoreflectance technique is based on the change of the sample reflection coefficient as a function of temperature. This small change in $10−4–10−5$ range per degree is typically detected using lock-in technique when the temperature of the device is cycled. Use of visible and near IR wavelength allows both top surface and through the substrate measurement. Both single point measurements using a scanning laser and imaging with charge coupled device or specialized lock-in cameras have been demonstrated. For ultrafast thermal decay measurement, pump-probe technique using nanosecond or femtosecond lasers has been demonstrated. This is typically used to measure thin film thermal diffusivity and thermal interface resistance. The spatial resolution of various optical techniques can be improved with the use of tapered fibers and near field scanning microscopy. While subdiffraction limit structures have been detected, strong attenuation of the signal reduces the temperature resolution significantly. Scanning thermal microscopy, which is based on nanoscale thermocouples at the tip of atomic force microscope, has had success in ultrahigh spatial resolution thermal mapping. Issues related to thermal resistance between the tip and the sample and parasitic heat transfer paths will be discussed.

1.
Kolzer
,
J.
,
Oesterschulze
,
E.
, and
Deboy
,
G.
, 1996, “
Thermal Imaging and Measurement Techniques for Electronic Materials and Devices
,”
Microelectron. Eng.
0167-9317,
31
(
1–4
), pp.
251
270
.
2.
Altet
,
J.
,
Claeys
,
W.
,
Dilhaire
,
S.
, and
Rubio
,
A.
, 2006, “
Dynamic Surface Temperature Measurements in ICs
,”
Proc. IEEE
0018-9219,
94
, pp.
1519
1533
.
3.
Cutolo
,
A.
, 1998, “
Selected Contactless Optoelectronic Measurements for Electronic Applications
,”
Rev. Sci. Instrum.
0034-6748,
69
, pp.
337
360
.
4.
Csendes
,
A.
,
Szekely
,
V.
, and
Rencz
,
M.
, 1996, “
Thermal Mapping With Liquid Crystal Method
,”
Microelectron. Eng.
0167-9317,
31
, pp.
281
290
.
5.
Vertikov
,
A.
,
Kuball
,
M.
,
Nurmikko
,
A. V.
, and
Maris
,
H. J.
, 1996, “
Time-Resolved Pumpprobe Experiments With Subwavelength Lateral Resolution
,”
Appl. Phys. Lett.
0003-6951,
69
, pp.
2465
2467
.
6.
Shi
,
L.
,
Kwon
,
O.
,
Miner
,
A. C.
, and
Majumdar
,
A.
, 2001, “
Design and Batch Fabrication of Probes for Sub-100 nm Scanning Thermal Microscopy
,”
J. Microelectromech. Syst.
1057-7157,
10
(
3
), pp.
370
378
.
7.
Tessier
,
G.
,
Hole
,
S.
, and
Fournier
,
D.
, 2001, “
Quantitative Thermal Imaging by Synchronous Thermoreflectance With Optimized Illumination Wavelengths
,”
Appl. Phys. Lett.
0003-6951,
78
(
16
), pp.
2267
2269
.
8.
,
D.
,
Hudgings
,
J. A.
,
Mayer
,
P. M.
, and
Ram
,
R. J.
, 2005, “
Nanoscale Thermoreflectance With 10 mK Temperature Resolution Using Stochastic Resonance
,”
Proceedings of the 21st IEEE Semi-Therm Symposium
,
San Jose, CA
.
9.
Burzo
,
M. G.
,
Komarov
,
P. L.
, and
,
P. E.
, 2005, “
Noncontact Transient Temperature Mapping of Active Electronic Devices Using the Thermoreflectance Method
,”
IEEE Trans. Compon. Packag. Technol.
1521-3331,
28
(
4
), pp.
637
643
.
10.
Christofferson
,
J.
, and
Shakouri
,
A.
, 2005, “
Thermoreflectance Based Thermal Microscope
,”
Rev. Sci. Instrum.
0034-6748,
76
, p.
024903
.
11.
Shakouri
,
A.
, and
Bowers
,
J. E.
, 1997, “
Heterostructure Integrated Thermionic Coolers
,”
Appl. Phys. Lett.
0003-6951,
71
, pp.
1234
1236
.
12.
Fitting
,
A.
,
Christofferson
,
J.
,
Shakouri
,
A.
,
Xiofeng
,
F.
,
Gehong
,
Z.
LaBounty
,
C.
,
Bowers
,
J. E.
, and
Croke
,
E.
, 2001, “
Transient Response of Thin Film SiGe Micro Coolers
,”
Proceedings of the International Mechanical Engineering Congress and Exhibition (IMECE 2001)
, Nov., New York.
13.
,
A.
, and
Eesley
,
G. L.
, 1986, “
Transient Thermoreflectance From Thin Metal Films
,”
J. Appl. Phys.
0021-8979,
60
, pp.
285
290
.
14.
Cahill
,
D. G.
, 1990, “
Thermal Conductivity Measurement From 30 to 750 K: The 3 Omega Method
,”
Rev. Sci. Instrum.
0034-6748,
61
, pp.
802
808
.
15.
Cahill
,
D. G.
,
Ford
,
W. K.
,
Goodson
,
K. E.
,
Mahan
,
G. D.
,
Majumdar
,
A.
,
Maris
,
H. J.
,
Merlin
,
R.
, and
Phillpot
,
S. R.
, 2003, “
Nanoscale Thermal Transport
,”
J. Appl. Phys.
0021-8979,
93
, pp.
793
818
.
16.
Ezzahri
,
Y.
,
Dilhaire
,
S.
,
Grauby
,
S.
,
Rampnoux
,
J. M.
,
Claeys
,
W.
,
Zhang
,
Y.
,
Zeng
,
G.
, and
Shakouri
,
A.
, 2005, “
Study of Thermomechanical Properties of Si/SiGe Superlattices Using Femtosecond Transient Thermoreflectance Technique
,”
Appl. Phys. Lett.
0003-6951,
87
, p.
103506
.
17.
Rossignol
,
C.
,
Perrin
,
B.
,
Bonello
,
B.
,
Djemia
,
P.
,
Moch
,
P.
, and
Hurdequint
,
H.
, 2004, “
Elastic Properties of Ultrathin Permalloy/Alumina Multilayers Films Using Picosecond Ultrasonics and Brillouin Light Scattering
,”
Phys. Rev. B
0163-1829,
70
, p.
094102
.
18.
Malyj
,
M.
, and
Griffiths
,
J. E.
, 1983, “
Stokes/Anti-Stokes Raman Vibrational Temperatures: Reference Materials, Standard Lamps, and Spectrophotometric Calibrations
,”
Appl. Spectrosc.
0003-7028,
37
, pp.
315
333
.
19.
LaPlant
,
F.
,
Laurence
,
G.
, and
Ben-Amotz
,
D.
, 1996, “
Theoretical and Experimental Uncertainty in Temperature Measurement of Materials by Raman Spectroscopy
,”
Appl. Spectrosc.
0003-7028,
50
, p.
1034
1038
.
20.
Shabani
,
J.
,
Wang
,
X.
, and
Shakouri
,
A.
, 2007, “
3D Temperature Measurement in IC Chips Using Raman Spectroscopy
,”
Proceedings of the Material Research Society Meeting
, Apr.,
San Francisco, CA
.